Removing Window From Spitfire 1500 Door

This page shows the specific location of each kind.

Removing window from spitfire 1500 door.

Removing old hood unclip front of frame and fold back. Remove the single screw that holds in door handle bezel by pulling on the handle with one hand and slipping the bezel off. I try to figure out why the driver s side door won t fit properly but then ignore that for a bit longer and move on to repair some cancer on the front of th. The window crank is held on by a small pin the photo shows the pin being put back in upon reassembly.

Keep track of what was where. Door panels roll window all the way down then remove the window crank handle by using two screwdrivers one to pry the panel and handle apart and one to carefully push out the retaining clip fig. Take off the door card and wind the window down as far as it will go. Easily said but more difficult to do.

Remove the nylon guide pieces from both ends. Triumph spitfire door trim panels and aperture seals original trim specification availability the very first spitfire was launched in october 1962 and production continued for nearly 20 years when the very last spitfire 1500 rolled off the production line in august 1980. This may also apply to 1988 1993 or later chevy gmc trucks. The chrome fitting around the inside door handle is held on by a single screw.

Remove the screw and snake the fitting off the handle. Door panel removal removal and installation of door panels. Note there are also rivets holding the front side window valance strap to the sides of the header rail that will need. Thanks for watching please rate.

Waist seal removal and refitting refitting the rubber and furry seals that run along the top of the door. The glass should just push up so you can lift it out the top. The gap in the top of the door is now wide enough to get the glass and its metal rubber u channel up and out. How to remove the window regulator on a 1993 chevy silverado.

Door clips placement there are two different door clips holding door panels on 1500 s. Raise the window up so that the front and then the rear ends of that frame are visible through the large holes in the door panel. Information on removing door panels on the triumph spitfires and gt6 s.